Product ID:30-0210 ALKYD ENAMEL UNDERCOATER
MSDS Date:09/15/1992
FSC:8010
NIIN:00N061229
MSDS Number: BXXGY

NUBRITE CHEM CO

601 SOUTH HAVEN ST
BALTIMORE, MD 21224
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 800-225-3530

Cage: JO071

NUBRITE CHEM CO

BALTIMORE, MD 21224 US

Telephone: 800-225-3530

Cage: JO071

NAPHTHA, HEAVY STRAIGHT RUN; (RULE 66 MINERAL SPIRITS) VP

CAS: 64741-41-9

Fraction By Weight: 53.00%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

CALCIUM CARBONATE (MARBLE) (LIMESTONE)

CAS: 1317-65-3

RTECS: EV9580000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

CLAYS

OSHA PEL N/K

ACGIH TLV: N/K

TALCS

OSHA PEL N/K

ACGIH TLV: N/K

PIGMENTS; (OTHER PIGMENTS)

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF HIGH VAPOR
CONCENTRATIONS MAY HAVE RESULTS, RANGING FROM MILD DEPRESSION TO
CONVULSIONS AND LOSS OF CONSCIOUSNESS. EYE OR SKIN CONTACT MAY
CAUSE DISCOMFORT. CHRONIC: PROLONGED OR REPEATED EXPOSURE TO HIGH
LEVELS MAY CAUSE BRAIN DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION: IF OVERCOME BY VAPOR, REMOVE FROM EXPOSURE
IMMEDIATELY. CALL MD. IF BREATHING IS IRREGULAR OR STOPPED, START
RESUSCITATION, ADMINISTER OXYGEN. SKIN: REMOVE CONTAMINATED
CLOTHING. WASH SKIN . EYES: FLUSH WITH WATER FOR AT LEAST 15
MINUTES UNTIL IRRITATION PERSISTS. INGESTION: CALL MD, DO NOT
INDUCE VOMITING OR GIVE ANYTHING BY MOUTH.

Flash Point Method:TCC
Flash Point:108F,42C
Lower Limits:0.7%
Extinguishing Media:CARBON DIOXIDE, FOAM, WATER FOG, DRY CHEMICAL. NFPA
CLASS B FIRE. BURNING LIQUIDS. USE CLASS B FIRE EXTING/EXTING
AGENT.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . COOL EXPOSED CONTAINERS WITH WATER. AVOID
BREATHING VAPOR OR FUMES.
Unusual Fire/Explosion Hazard:KEEP CONTAINER TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAME, HOT
SURFACES, ELECTRICAL). VENTILATE AREA. CONTAIN & REMOVE W/INERT
ABSORBENT MATERIAL & NON-SPARKING TOOLS. DO NOT FLUSH W/WATER, USE
SAND/OTHER INERT MATERIAL TO DAM/CONTAIN SPILL IN CASE OF LARGE
RELEASES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE ABOVE 110F. DO NOT STORE
OR USE NEAR HEAT, SPARKS OR FLAME. NO SMOKING OR OPEN LIGHTS.
Other Precautions:STORE LARGE QUANTITY IN COMPLIANCE WITH OSHA 29 CFR
1910.106. THIS PRODUCT CONTAINS THESE TOXIC CHEMICALS SUBJECT TO
REPORTING REQUIREMENTS SEC 313 OF EMERGENCY PLANNING AND COMMUNITY
RIGHT-TO-KNOW AC T OF 1986 AND OF CFR.

Respiratory Protection:USE NIOSH/MSHA APPROVED MECHANICAL FILTER
RESPIRATOR. HYDROCARBON VAPOR CANISTER.
Ventilation:EXPLOSION-PROOF VENTILATION EQUIPMENT. LOCAL EXHAUST. FACE
VELOCITY 60 FPM.
Protective Gloves:USE CHEMICAL-RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . USE CHEMICAL-RESISTANT APRON IF NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

Boiling Pt:B.P. Text:>317F,>158C
Vapor Pres:(SEE ING1)
Vapor Density:HVR/AIR
Spec Gravity:1.28
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:53(WT)

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR OXIDIZING AGENTS AND SELECTED AMINES.
Stability Condition to Avoid:SEE SPILL PROCEDURES, WASTE DISPOSAL
METHOD, HANDLING/STORAGE PRECAUTIONS, AND OTHER PRECAUTIONS
SECTIONS.
Hazardous Decomposition Products:CARBON MONOXIDE AND/OR CARBON DIOXIDE
IN CASE OF INCOMPLETE COMBUSTION.

Waste Disposal Methods:KEEP PETROLEUM PRODUCTS OUT OF STREAMS &
WATERWAYS. DISPOSE IN ACCORDANCE W/LOCAL, STATE, & FEDERAL
REGULATIONS. IN CASE OF LARGE SPILL, USE LICENSED HAZARDOUS WASTE
DISPOSAL COMPANY. DO NOT INCINERAT E CLOSED CONTAINERS IMMEDIATELY
IMMERSED IN WATER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.